Optimasi Teknik Penyambungan Peralon Bawah Tanah untuk Sistem Saluran Pembuangan Domestik, Studi Kasus di PT XYZ

Daris Permana; Nanang Burhan

doi:10.33504/manutech.v18i01.864

Authors

Daris Permana Universitas Sigaperbangsa Karawang
Nanang Burhan Universitas Sigaperbangsa Karawang

DOI:

https://doi.org/10.33504/manutech.v18i01.864

Keywords:

pipe jointing, drainage syste, leakage, optimization, jointing technique

Abstract

The domestic drainage system is a crucial component in maintaining environmental health and public comfort. One of the key elements in this system is the PVC pipe (peralon), commonly used for underground drainage pipes. Suboptimal pipe jointing can lead to leakage, blockage, or damage due to soil pressure and external load, reducing system efficiency and increasing maintenance costs. This study aims to analyze and optimize the underground PVC pipe jointing technique at PT XYZ. The research was conducted using field observations, interviews with technicians, and leakage tests on pipe joints. The results indicate that joint quality is significantly influenced by factors such as pipe surface cleaning, drying time of adhesive, and soil conditions. The implementation of standardized procedures, proper bedding slope adjustments, and leakage testing were shown to reduce leakage by 90% and improve installation efficiency. This optimization is expected to enhance joint quality, extend the lifespan of the drainage system, and reduce maintenance costs.

Downloads

Download data is not yet available.

References

[1] A. Furukawa, A. Ito, K. Asano, M. Okutsu, and C. Author, “SAFETY EVALUATION OF OLD-STANDARD RIGID PVC PIPES WITH ADHESIVE JOINTS IN THE EVENT OF FAULT,” vol. 24, no. 101, pp. 1–11, 2023.

[2] C. Shan and W. Li, “Mechanical performance of buried pipe under traffic load-internal pressure coupling action?: Experimental and numerical study,” pp. 1–28, 2025, doi: 10.1371/journal.pone.0335464.

[3] A. I. Tawakal, P. Studi, T. Lingkungan, and U. Islam, “PERENCANAAN JARINGAN PERPIPAAN AIR LIMBAH PENCUCIAN LOKOMOTIF DI PT . KERETA API INDONESIA ( PERSERO ), UPT . BALAI YASA YOGYAKARTA,” pp. 1–17.

[4] G. Sukati, G. Sukati, and L. Tahapan, “PERENCANAAN SISTEM PENYALURAN AIR BUANGAN PADA KOMPLEK PERUMAHAN GRAND SUKATI, " pp. 1–10.

[5] C. Engineering, “Analysis of Variations in Deflection and Stresses in Buried PVC Pipe Protected With an Eps Geofoam Layer,” vol. 9, no. 3, pp. 105–113, 2018.

[6] A. Rudawska, M. A. Wahab, M. Müller, and D. Stan?, “Mechanical Properties and Leak-Tightness of Polymeric Pipe Adhesive Joints,” pp. 64–77, 2022.

[7] L. Design et al., “A review on the durability of PVC sewer pipes?: research vs . practice,” vol. 2479, 2020, doi: 10.1080/15732479.2019.1673442.

[8] H. Kang, J. Y. Kim, Y. Kim, S. Park, and J. Kim, “Experimental Evaluation of Water Supply Pipe Joints against Seismic Ground Deformation?: A Four-point Bending Test,” vol. 28, no. 3, pp. 0–3, 2023.

[9] A. Rudawska, I. Miturska, M. A. Wahab, D. Stan?eková, and M. ?avodová, “Influence of the Assembly Method of Sleeve Joints on Their Strength,” Manuf. Technol., vol. 20, no. 5, pp. 660–667, 2020, doi: 10.21062/mft.2020.093.

[10] U. Forestry, U. Greening, Ö. Johan, M. Max, S. Örjan, and F. Ann-mari, “This is an author produced version of a paper published in Urban Forestry & Urban Greening . This paper has been peer-reviewed and is Citation for the published paper?: intrusion by tree and shrub species into sewer pipes in Swedish urban Risk of root intrusion by tree and shrub species into sewer pipes in Swedish urban areas,” 2012.